Phase transition temperature reduction and glass formation in dehydroprotected lyophilized liposomes

https://doi.org/10.1016/0168-3659(94)90253-4Get rights and content

Abstract

Two prevailing theories for dry membrane preservation are the water replacement hypothesis and glass formation. A manifestation of the water replacement hypothesis is the ability of sugars to depress dry membrane main phase transition temperatures (Tm). Differential scanning calorimetry (DSC) was employed to test the effects of sugars (trehalose, α-lactose, maltose and glucose) on the Tms of slowly frozen, lyophilized liposomes prepared from hydrogenated egg phosphatidycholine [HEPC], dipalmitoylphosphatidylcholine [DPPC] and palmitoyloleoylphosphatidylcholine [POPC]. For each lyophilized phospholipid membrane, the disaccharides caused significant Tm reduction to at least 14°C below the hydrated membrane Tms. The Tm-reduction was achieved by heating the lyophilized product: an annealing process that included a membrane phase transition and a disaccharide glass transition. Thermogravimetric analysis (TGA) showed residual water loss (3–6%) during annealing and FTIR spectra suggested an annealing-induced disaccharide/phospholipid-carbonyl interaction. Scanning electron microscopy (SEM) showed an amorphous appearance of the lyophilized trehalose/HEPC matrix, which was confirmed by DSC to be glassy, and which remained intact after annealing. Also observed with SEM were membrane infolding, fusion of unprotected liposomes, and matrix porosity. Discussed are the potential implications of annealing, dry membrane Tm-reduction and glass formation for liposome dehydroprotection.

References (35)

  • J.C.M. Stewart

    Calorimetric determination of phospholipids with ammonium ferrothiocyanate

    Anal. Bioch.

    (1980)
  • P.T.T. Wong et al.

    High-pressure infrared spectroscopic evidence of water binding sites in 1,2-diacyl phospholipids

    Chem. Phys. Lipids

    (1988)
  • J. Grdadolnik et al.

    Hydration of phosphatidylcholine reverse micelles and multilayers: an infrared spectroscopic study

    Chem. Phys. Lipids

    (1991)
  • G.J. Fransen et al.

    Critical parameters in the freezing of liposomes

    Int. J. Pharmaceut.

    (1986)
  • F. Franks

    Solute-water interactions: do polyhydroxycompounds alter the properties of water?

    Cryobiology

    (1983)
  • F. Franks et al.

    Water, temperature and life

    Phil. Trans. R. Soc. London B

    (1990)
  • W.P. Williams

    Cold-induced lipid phase transitions

    Phil. Trans. R. Soc. London B

    (1990)
  • Cited by (52)

    • Low temperature, easy scaling up method for development of smart nanostructure hybrid lipid capsules for drug delivery application

      2020, Colloids and Surfaces B: Biointerfaces
      Citation Excerpt :

      However, lyophilization without trehalose results in drastic reduction of particle size indicating possible destruction of nHLCs structure during lyophilization. The little change in size of lyophilized nHLCs with optimum trehalose composition (≥10 %) upon rehydration (smaller than non-lyophilized) may be due to possible interaction of sugar molecules with molecules of nHLCs membrane as well as forming surrounding glassy-matrix [39]. Fig. SI-3 shows the camera images of the non-lyophilized nHLCs, lyophilized powder and rehydrated lyophilized suspension of nHLCs.

    • Evaluation of various tissue-clearing techniques for the three-dimensional visualization of liposome distribution in mouse lungs at the alveolar scale

      2019, International Journal of Pharmaceutics
      Citation Excerpt :

      Liposomes are believed to be disrupted by surface-active agents in a concentration-dependent manner (Domecq et al., 2001; Petralito et al., 2014). In this study, because our liposomes were composed of HEPC with a high phase transition temperature (52 °C) (Mobley and Schreier, 1994), the liposomes have high stability and low pre-leakage of the encapsulated drugs. In addition, encapsulated FITC-dextran has low permeability through liposomal membranes based on its high molecular weight (10 kDa).

    View all citing articles on Scopus
    View full text