Abstract
Mass transfer and terminal velocity of toluene drops rising in an extraction column was studied experimentally. The impact of packing was investigated by inserting a structured packing in three different heights of 10, 25 and 40 cm inside the column. The effect of packing height, flow rate and drop size on terminal velocity and Sherwood number were investigated and the results were also compared with the case of non-packed column. It was discussed that a 30% increase in Sherwood number could be achieved using the packing with 40 cm in height. It was also found that for Eötvös number, Eö, higher than 0.4, the deformation of drops and velocity oscillation appeared, which affected the terminal velocity. Finally, two correlations were proposed, which permitted the prediction of deformation and extraction ratio versus the dimensionless numbers of Reynolds, Eötvös and the packing height ratio.
Similar content being viewed by others
Abbreviations
- AR:
-
Aspect ratio of drop, (dvert./dhor)
- \(c\) :
-
Solute concentration in dispersed phase (kg/m3)
- \(c_{0}\) :
-
Initial concentration of solute in dispersed phase (kg/m3)
- \(c^{*}\) :
-
Equilibrium concentration of solute in dispersed phase (kg/m3)
- \(d\) :
-
Drop size (m)
- \(d_{N}\) :
-
Needle size of nozzle (mm)
- \(D\) :
-
Molecular diffusivity (m2/s)
- E:
-
Extraction ratio (–)
- Eö:
-
Eötvös number \((\frac{{(\rho_{c} - \rho_{d} )gd^{2} }}{\gamma })\)
- h:
-
Rising distance (cm)
- hp:
-
Packing height (cm)
- \(k\) :
-
Mass transfer coefficient (m/s)
- M:
-
Molecular weight of solvent (kg/kmol)
- Q:
-
Volumetric flow rate of dispersed phase (ml/min)
- Re:
-
Reynolds number \(\left( {\frac{{\rho_{c} u_{t} d}}{{\mu_{c} }}} \right)\)
- Sh:
-
Sherwood number \(\left( { = \frac{{k_{d} d}}{{D_{A,m} }}} \right)\)
- t:
-
Rising time (s)
- T:
-
Temperature (K)
- \(u_{t}\) :
-
Terminal velocity of a single drop (m/s)
- V:
-
Molar volume at normal boiling temperature (m3/kmol)
- We:
-
Weber number, \(\left( {\frac{{\rho_{c} u_{t}^{2} d}}{\gamma }} \right)\)
- \(\gamma\) :
-
Interfacial tension (N/m)
- \(\mu\) :
-
Viscosity (Pa.s)
- \(\varphi\) :
-
Association factor of the solvent (= 2.6 for water)
- \(\rho\) :
-
Density (kg/m3)
- \(\Delta \rho\) :
-
Density difference (ρc- ρd), (kg/m3)
- A:
-
Solute
- \(c\) :
-
Continuous phase
- crit:
-
Critical
- d :
-
Dispersed phase
- hor.:
-
Horizontal
- i:
-
Counter
- m:
-
Mixture
- np:
-
Non-Packed
- o:
-
Overall
- p:
-
Packed
- vert.:
-
Vertical
References
Al Taweel AM, Li C, Gomaa HG, Yuet P (2007) Immiscible liquids using screen-type static mixers. Trans IChemE 85(Part A):760–7655
Saien J, Daliri S (2014) Improving performance of liquid–liquid extraction with temperature for mass transfer resistance in both phases. J Taiwan Inst Chem Eng 45:808–814
Saadat Gharehbagh F, Mousavian SMA (2009) Hydrodynamic characterization of mixer-settlers. J Taiwan Inst Chem Eng 40:302–312
Pich’e S, Iliuta I, Grandjean BPA, Larachi F (2001) A unified approach to the hydraulics and mass transfer in randomly packed towers. Chem Eng Sci 56:6003–6013
Verma RP, Sharma MM (1975) Mass transfer in packed liquid-liquid extraction columns. Chem Eng Sci 30:279–292
Slater MJ, Baird MHI, Liang TB (1988) Drop phase mass transfer coefficients for liquid-liquid systems and the influence of packings. Chem Eng Sci 43:233–245
Azizi Z, Rezaeimanesh M (2016) Packing effect on mass transfer and hydrodynamics of rising toluene drops in stagnant liquid. Chem Eng Res Des 115:44–52
Batey W, Thornton JD (1989) Partial mass-transfer coefficients and packing performance in liquid–liquid extraction. Ind Eng Chem Res 28:1096–1101
Koncsag CI, Barbulescu A (2008) Modelling the removal of mercaptans from liquid hydrocarbon streams in structured packing columns. Chem Eng Process 47:1717–1725
Jie Y, Weiyang F, Li HZ (2005) Effect of packing on drop swarms extraction of high viscosity solvents. Hydrometallurgy 78:30–33
Salimi-Khorshidi A, Abolghasemi H, Khakpay A, Kheirjooy Z, Esmaieli M (2013) Spray and packed liquid–liquid extraction columns: drop size and dispersed phase mass transfer. Asia-Pac J Chem Eng 8:940–949
Azizi Z, Rezaeimanesh M, Abolghasemi H, Bahmanyar H (2014) Effective diffusivity in a structured packed column: experimental and Sherwood number correlating study. Chem Eng Res Des 92:43–53
Su Y, Zhao Y, Chen G, Yuan Q (2010) Liquid–liquid two-phase flow and mass transfer characteristics in packed microchannels. Chem Eng Sci 65:3947–3956
Wegener M, Paul N, Kraume M (2014) Fluid dynamics and mass transfer at single droplets in liquid/liquid systems. Int J Heat Mass Transfer 71:475–495
Wegener M, Grünig J, Stüber J, Paschedag AR, Kraume M (2007) Transient rise velocity and mass transfer of a single drop with interfacial instabilities – experimental investigations. Chem Eng Sci 62:2967–2978
You XY, Zhang LD, Zheng JR (2014) Marangoni instability of immiscible liquid–liquid stratified flow with a planar interface in the presence of interfacial mass transfer. J Taiwan Inst Chem Eng 45:772–779
Wegener M, Fevre M, Paschedag AR, Kraume M (2009) Impact of Marangoni instabilities on the fluid dynamic behaviour of organic droplets. Int J Heat Mass Transf 52:2543–2551
Thorsen G, Stordalen RM, Terjesen SG (1968) On the terminal velocity of circulating and oscillating liquid drops. Chem Eng Sci 23:413–426
Bäumler K, Wegener M, Paschedag AR, Bänsch E (2011) Drop rise velocities and fluid dynamic behavior in standard test systems for liquid/liquid extraction—experimental and numerical investigations. Chem Eng Sci 66:426–439
Rahbar A, Azizi Z, Bahmanyar H, Moosavian MA (2011) Prediction of enhancement factor for mass transfer coefficient in regular packed liquid-liquid extraction columns. Can J Chem Eng 89:508–519
Zappe J, Wesch A, Ebert KH (2000) Measurement of the mass transfer into single drops in the system of water/supercritical carbon dioxide. J Colloid Interface Sci 231:1–7
Wei H, Fei W. Study on multi-component mass transfer coefficient of drop swarms. In: Proceedings of the 4th international conference on separation science and technology: frontiers on separation science and technology, 2004; Nanning, Guangxi, China
Saien J, Bamdadi H (2012) Mass transfer from nanofluid single drops in liquid − liquid extraction process. Ind Eng Chem Res 51:5157–5166
Drelich J, Fang C, White CL (2002) Encyclopedia of surface and colloid science. Dekker, New York
Poling BE, Prausnitz JM, O’Connell JP. The Properties of Gases and Liquids, 5th ed., McGraw-Hill; 2001. doi: 10.1036/0070116822
Slater MJ, Godfrey JC (1994) Liquid-liquid extraction equipment. Wiley, Chichester, pp 45–94
Saien J, Bamdadi H, Daliri S (2015) Liquid–liquid extraction intensification with magnetite nanofluid single drops under oscillating magnetic field. J Ind Eng Chem 21:1152–1159
Klee AJ, Treybal RE (1956) Rate of rise or fall of liquid drops. AIChE J 2:444–447
Michaelides EE (2006) Particles, bubbles and drops. World Scientific Publishing, Singapur
Hu S, Kintner RC (1995) The fall of single liquid drops through water. AIChE J 1:42–48
Krishna PM, Venkateswarlu D, Narasimhamurty GSR (1959) Fall of liquid drops in water, terminal velocities. J Chem Eng Data 4:336–340
Winnikow S, Chao BT (1966) Droplet motion in purified systems. Phys Fluids 9:50–61
Misek T, Marek J (1970) Asymmetric rotating disc extractor. Br Chem Eng 15:202–207
Grace JR, Wairegi T, Nguyen TH (1976) Shapes and velocities of single drops and bubbles moving freely through immiscible liquids. Trans Inst Chem Eng 54:167–173
Eiswirth RT, Bart HJ, Atmakidis T, Kenig EY (2011) Experimental and numerical investigation of a free rising droplet. Chem Eng Process 50:718–727
Komasawa I, Ingham I (1978) Effect of system properties on the performance of liquid–liquid extraction columns-1Packed column. Chem Eng Sci 33:341–347
Handlos AE, Baron T (1957) Mass and heat transfer from drops in liquid–liquid extraction. AIChE J 3:127–136
Engberg RF, Wegener M, Kenig EY (2014) The influence of Marangoni convection on fluid dynamics of oscillating single rising droplets. Chem Eng Sci 117:114–124
Azizi Z, Rahbar A, Bahmanyar H (2010) Investigation of packing effect on mass transfer coefficient in a single drop liquid extraction column. IJChE 7(4): 3–11
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Azizi, Z. Experimental investigation of terminal velocity and Sherwood number of rising droplet in an extraction column. Heat Mass Transfer 53, 3027–3035 (2017). https://doi.org/10.1007/s00231-017-2037-0
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s00231-017-2037-0